Flat Roof Repair in Molalla OR 97038

Locally Owned & Operated

HOME PROS ROOFING

Looking for the right Roofing company for your home or property? Since 1980 we have been providing Roofing services to the Molalla area.

(844) 359-2189

(Molalla OR 97038) –

If you’re looking for flat roof repair information, you’ve come to the right place. The procedure varies with the type of roofing system, but here are the steps for the most common type where I live.

It is called “modified bitumen” (pronounced buy-TOO-men) and consists of a tough mat embedded in a special asphalt formula that includes elastic additives. That allows the material to expand and contract with Choose an EPDM ... Molalla OR 97038 temperature changes. The surface is covered with ceramic granules to provide solar protection.

Modified bitumen or “modified” as it is usually called, is especially popular on small residential jobs. That’s because it doesn’t require a hot asphalt kettle along with the inherent safety hazards and obnoxious fumes.

Modified can be installed several different ways, but one of the most common methods is with a propane torch. That is also Molalla OR 97038 the technique responsible for most of the leak problems with this system when the seams are not heated properly. If you overheat the material, too much asphalt flows away from the seam. Not enough heat results in cold seams that are not completely bonded. Either case creates seams that are vulnerable to water intrusion. If the roof ponds water and the roofer didn’t install a protective mid-ply, Flat Roof Challenges Molalla OR 97038 leaks are nearly inevitable.

Fortunately, this is a fairly simple flat roof repair. You will need these materials:

Flashing cement. Be sure to get the MB (modified bitumen) variety, as the standard type is not 100% compatible.

Membrane. Either 4″ or 6″ is fine, but be sure to get fiberglass rather than cotton, as it lasts a lot longer.

Granules. For a small repair, you might find enough loose ones on Molalla OR 97038 the roof or in the gutter to reuse.

Start by CAREFULLY probing the seams with a small pen knife, looking for voids. Ideally, the seams should have about ½” of asphalt bleed-out. Any areas that don’t are suspect.

The seams need to be both clean and dry to get a good flat roof repair. Spread a thin layer of flashing cement directly over the problem area, slightly wider than Molalla OR 97038 your membrane. Test the bond you are making by “tapping” the cement with your trowel. If it comes up, leaving bare patches of modified, the surface is still too wet or too dirty.

Next, keeping the membrane taunt, set it in the thin bed of flashing cement. Work it in with your trowel until the membrane is embedded tightly.

Then spread another layer of flashing cement over the membrane. Molalla OR 97038 Again, you don’t need a lot. Just enough to cover the scrim is sufficient.

To complete your flat roof repair, broadcast granules into the fresh cement. That will dress up the repair and protect it from the sun.

Video: COMMERCIAL FLAT ROOF REPAIR

Video: Flat Roof Repair - Unprotected Torch Down Rubber Roof

Video: How to install a Classicbond EPDM flat Roof

Video: Flat Roofing - 2 Ways to Find Leaks in Modified Bitumen Rolled Roofing

Video: Flat Roofing - 2 Ways to Find Leaks in Modified Bitumen Rolled Roofing

Video: DIY Flat Roof Repair - Easy Paint on Fix

Business Results 1 - 10 of 3

West Coast Roofing & Painting
22 Reviews
Roofing, Painters
Phone:
2442 SE 101st Ave, Ste 308, Portland, OR 97216

DaBella Exteriors
66 Reviews
Roofing, Windows Installation, Siding
Phone:
10300 SW Nimbus Ave, Ste P-B, Portland, OR 97223

Executive Roof Services
1 Reviews
Roofing, Gutter Services
Phone:
Vancouver, WA 98660

Business Results 1 - 10 of 20

Frontier Roofing and Construction LLC



Pioneer Roofers



Roof Masters Inc.



Cascade Roofing Portland



Dial One Roofing of Oregon Inc.



Roofers – Salem, Oregon



Pacific West Roofing



Atlas Roofing & Construction



Legit Roofing



Western Pacific Roofing



GET A QUOTE NOW

For quality workmanship and service for your residential and commercial Roofing needs, choose a company with over 38 years of service in the Molalla area.

Highly Rated

Integrity, quality workmanship and attention to detail have made us one of the most reliable Roofing companies in Molalla.

Quality Service

We focus on making the process as least disruptive as possible to our clients

Affordable Prices

We work hard to keep our costs low and transfer these efficiency savings on to our customers

100% Oregon Licensed Experts

We can complete any size project  in a timely manner, without skipping any steps  or cutting any corners.

GET A QUOTE NOW

(844) 359-2189