Flat Roof Repair in Merrillville IN 46410

Locally Owned & Operated

HOME PROS ROOFING

Looking for the right Roofing company for your home or property? Since 1980 we have been providing Roofing services to the Merrillville area.

(844) 359-2189

(Merrillville IN 46410) –

If you’re looking for flat roof repair information, you’ve come to the right place. The procedure varies with the type of roofing system, but here are the steps for the most common type where I live.

It is called “modified bitumen” (pronounced buy-TOO-men) and consists of a tough mat embedded in a special asphalt formula that includes elastic additives. That allows the material to expand and contract with Fixing That Leaky Flat Roof With A Low Sloped Roofing System Merrillville IN 46410 temperature changes. The surface is covered with ceramic granules to provide solar protection.

Modified bitumen or “modified” as it is usually called, is especially popular on small residential jobs. That’s because it doesn’t require a hot asphalt kettle along with the inherent safety hazards and obnoxious fumes.

Modified can be installed several different ways, but one of the most common methods is with a propane torch. That is also Merrillville IN 46410 the technique responsible for most of the leak problems with this system when the seams are not heated properly. If you overheat the material, too much asphalt flows away from the seam. Not enough heat results in cold seams that are not completely bonded. Either case creates seams that are vulnerable to water intrusion. If the roof ponds water and the roofer didn’t install a protective mid-ply, Best Ways to Do Flat Roof Repair Merrillville IN 46410 leaks are nearly inevitable.

Fortunately, this is a fairly simple flat roof repair. You will need these materials:

Flashing cement. Be sure to get the MB (modified bitumen) variety, as the standard type is not 100% compatible.

Membrane. Either 4″ or 6″ is fine, but be sure to get fiberglass rather than cotton, as it lasts a lot longer.

Granules. For a small repair, you might find enough loose ones on Merrillville IN 46410 the roof or in the gutter to reuse.

Start by CAREFULLY probing the seams with a small pen knife, looking for voids. Ideally, the seams should have about ½” of asphalt bleed-out. Any areas that don’t are suspect.

The seams need to be both clean and dry to get a good flat roof repair. Spread a thin layer of flashing cement directly over the problem area, slightly wider than Merrillville IN 46410 your membrane. Test the bond you are making by “tapping” the cement with your trowel. If it comes up, leaving bare patches of modified, the surface is still too wet or too dirty.

Next, keeping the membrane taunt, set it in the thin bed of flashing cement. Work it in with your trowel until the membrane is embedded tightly.

Then spread another layer of flashing cement over the membrane. Merrillville IN 46410 Again, you don’t need a lot. Just enough to cover the scrim is sufficient.

To complete your flat roof repair, broadcast granules into the fresh cement. That will dress up the repair and protect it from the sun.

Video: Flat Roof Installation - BAC Enterprises - New Mexico Roofer - IB Roof Systems

Video: Flat roof edge leaking for a wile

Video: Flat Roofing - 2 Ways to Find Leaks in Modified Bitumen Rolled Roofing

Video: Toronto Roof Repair - Flat Roof Repair - 2/2

Video: How to Patch a Leaking Rubber Roof - This Old House

Video: How to repair a leaky roof | Watco

Business Results 1 - 10 of 8

Total Roofing & Construction Services
3 Reviews
Roofing, Contractors, Gutter Services
Phone:
833 E 158th St, Dolton, IL 60419

Sanchez Roofing & Construction
2 Reviews
Roofing, Siding, Gutter Services
Phone:
852 Hoffman St, Hammond, IN 46327

Kusiak Construction
2 Reviews
Roofing, Windows Installation, Gutter Services
Phone:
8338 Kennedy Ave, Highland, IN 46322

Affordable Restoration Group
3 Reviews
Contractors, Damage Restoration, Roofing
Phone:
8604 W 95th, Ste 101, Hickory Hills, IL 60457

Eenigenburg Exteriors
1 Reviews
Roofing, Siding, Gutter Services
Phone:
13926 W 117th Ave, Cedar Lake, IN 46303

Berg Roofing & Home Improvements
12 Reviews
Roofing, Windows Installation, Gutter Services
Phone:
900 Ogden Ave, Ste 155, Downers Grove, IL 60515

Waukegan Roofing
7 Reviews
Roofing
Phone:
1320 Gladstone Ave, Waukegan, IL 60085

Attic Air
33 Reviews
Insulation Installation
Phone:
308 State Ave, St. Charles, IL 60103

GET A QUOTE NOW

For quality workmanship and service for your residential and commercial Roofing needs, choose a company with over 38 years of service in the Merrillville area.

Highly Rated

Integrity, quality workmanship and attention to detail have made us one of the most reliable Roofing companies in Merrillville.

Quality Service

We focus on making the process as least disruptive as possible to our clients

Affordable Prices

We work hard to keep our costs low and transfer these efficiency savings on to our customers

100% Indiana Licensed Experts

We can complete any size project  in a timely manner, without skipping any steps  or cutting any corners.

GET A QUOTE NOW

(844) 359-2189